Dodecyl Amine Polyoxyethylene Ether AC-1210 is a non-ionic surfactant with weak cationic properties. Under normal usage conditions, it is relatively safe, but strict operating procedures must still be followed. This product is classified as Skin Irritant Category 2 and Serious Eye Irritant Category 2, with the signal word "Warning". It is toxic to aquatic life with long-lasting effects (Category 3). Therefore, both personal protection and environmental protection must be considered during use.
During operation, ensure good ventilation in the work area to avoid accumulation of vapor or spray. Eating, smoking, and drinking are prohibited during operation. After operation, hands and any exposed skin must be thoroughly washed. Contaminated protective equipment must be thoroughly cleaned before reuse, and work clothes should be stored separately and not taken out of the workplace.
The product should be stored in a cool, dry, well-ventilated place with the container tightly closed. The recommended storage temperature is between 5 and 40°C to prevent freezing or overheating degradation. Keep away from incompatible materials such as strong oxidizers, strong acids, and strong bases. Under recommended storage conditions, the product shelf life can be up to two years.
| Protection Item | Specific Requirements |
|---|---|
| Respiratory Protection | If exposure to vapor or spray is possible, wear appropriate respiratory protective equipment. |
| Hand Protection | Wear chemically resistant nitrile rubber protective gloves with a thickness of at least 0.4 mm. |
| Eye Protection | Wear tight-fitting chemical safety goggles. |
| Skin and Body Protection | Wear chemical protective clothing to avoid direct skin contact. |
| Engineering Controls | Keep the work area ventilated and equip with emergency eyewash stations and shower facilities. |
Skin Contact: Immediately remove all contaminated clothing and rinse skin thoroughly with plenty of water and mild soap for at least 15 minutes. If irritation persists, seek medical attention immediately.
Eye Contact: Lift eyelids and rinse continuously with flowing water or saline for at least 15 minutes, then seek immediate medical attention. This is one of the most critical risks to be aware of, as the product can cause serious eye irritation.
Inhalation: Quickly move to fresh air and maintain an open airway. If breathing stops, immediately perform artificial respiration and seek medical attention.
Ingestion: Rinse mouth with water; do not induce vomiting. If the person is conscious, give a small amount of water to drink. Seek medical attention immediately and show the product safety data sheet or container label.
Leak Handling: For small spills, absorb with inert absorbent materials (e.g., sand, diatomaceous earth) and collect in a closed chemical waste container. For large spills, dike and contain, then transfer to a dedicated container using an explosion-proof pump for recovery. Wash water must be collected and disposed of in accordance with local environmental regulations; do not discharge directly into the environment.